Why did the Boeing 787 fail?

Deliveries of the Boeing 787 were stopped by the FAA in May 2021 after production flaws surfaced and concerns over Boeing's inspection methods. The FAA then declared in February 2022 that it would not allow Boeing to self-certify the completion of each 787 aircraft.



People Also Ask

The FAA said the leaks could damage critical equipment and lead to a “loss of continued safe flight and landing.” The agency said one airline found wet carpet in the cockpit of a plane and, when it inspected its entire fleet of 787s, found “multiple” planes with leaking faucets.

MORE DETAILS

The Boeing 787 is one of the newest planes to come into passenger service. First delivered in 2011, the aircraft has become a favorite for airlines thanks to its extensive range and fuel efficiency. And, for passengers, the travel experience was much better compared to older aircraft.

MORE DETAILS

The longer the 787s remained on the ground, the more it would cost to get them to fly again, due to the maintenance work required. As a result, they were no longer airworthy.

MORE DETAILS

On January 17th, 2013, the FAA ordered the entire 787 fleet across all airlines to be grounded, and the NTSB launched an investigation. The culprit was eventually identified as a lithium-ion battery. A cell within the battery was believed to have short-circuited, causing what is known as a thermal runaway.

MORE DETAILS

Boeing stops deliveries of 787 passenger jet to further analyze fuselage component Boeing has again stopped deliveries of its 787 passenger jet because of questions around a supplier's analysis of a part near the front of the plane, company and federal officials said Thursday.

MORE DETAILS

The Bottom Line: The Airbus A350-900 and Boeing 787-9 are very similar aircraft, suited for similar missions. As one would expect, the slightly larger A350-900 has a seat-mile cost advantage, while the 787-9 has an advantage in cost per block hour. These aircraft are competitive, and nearly tie in economic performance.

MORE DETAILS

The Bottom Line: The Airbus A350-900 and Boeing 787-9 are very similar aircraft, suited for similar missions. As one would expect, the slightly larger A350-900 has a seat-mile cost advantage, while the 787-9 has an advantage in cost per block hour. These aircraft are competitive, and nearly tie in economic performance.

MORE DETAILS

Did you know that the 787 can deploy a propellor underneath its fuselage? It's called a RAT.

MORE DETAILS

The problem involves a fitting for the 787's horizontal stabilizer installed by a Boeing production facility in Salt Lake City, Utah, the company said. The horizontal stabilizer, located at the base of an aircraft's tail, allows a plane to maintain longitudinal balance while flying.

MORE DETAILS

No profits on the 787 The 787 Dreamliner charges included a $3.5 billion write-off to cover what Boeing will have to pay as compensation to airlines for the delivery delays that it says extend further than previously anticipated.

MORE DETAILS

All large commercial jets can land automatically, but still with plenty of pilot involvement. So-called autoland systems are a part of aircraft autopilots. All large modern jets are equipped with such systems, which can automatically land the aircraft, albeit under careful supervision from the pilots themselves.

MORE DETAILS

The typical lifespan of airliners The composite-driven Boeing 787 Dreamliner is designed for 44,000 flight cycles. These jets can theoretically last several decades with an average of two flight cycles a day.

MORE DETAILS

The Dreamliner's lightweight composite structure contributes to reduced noise levels, both inside and outside the aircraft. The use of advanced soundproofing materials and quieter engines keeps the cabin environment more tranquil for passengers.

MORE DETAILS

The Boeing 777 series is larger than the 787 and thus can carry more passengers. The 787-10 has a higher capacity than the smaller 777-200 series. However, it falls short of the larger 777-300 models by 66 passengers in a typical two-class configuration. Of course, the exact capacity varies from airline to airline.

MORE DETAILS

If you're flying economy class, the A380 will be a way better experience. Seat width on 9 abreast dreamliners is about 17.5. If you get a window seat like any other avgeek there's a good chance the wall between windows takes away an inch of shoulder space.

MORE DETAILS